Tech section strictly for the FJR. Everything from oil changes & suspension setup's to removing sheep hair from hard to reach places on the bike so that your wife never finds out.
268 Replies
488220 Views
Last post by bill lumberg
Sun Mar 09, 2025 6:26 pm
Where is the “Off Topic” area?
Replies: 19
by
extrememarine »
Fri Jan 18, 2013 9:47 pm
» in
Introductions
First post
Where is the “Off Topic” area?
Last post
Thank you - link updated!
19 Replies
104664 Views
Last post by extrememarine
Tue Aug 27, 2024 9:43 am
Ground Spiders on Gen2 FJR's
Replies: 27
by
raYzerman »
Fri Nov 17, 2017 6:24 pm
First post
Suggest making this a sticky..... Thought I would post this up separately so you don't have to go searching through other threads.. Note, Gen3 has...
Last post
Luckily the first spider I could find was S6, and it had some slight scorching marks on it, but the wiring itself appeared undamaged. I pulled out...
27 Replies
24395 Views
Last post by mcatrophy
Wed Jun 15, 2022 2:08 pm
PAIR / AIS Block Off Plugs or Plates - All Gens.
Replies: 2
by
raYzerman »
Sat Mar 29, 2025 11:44 am
First post
For those wanting to remove their PAIR/AIS system, and not install block-off plates, here is an interesting alternative, cheap and EZ. Just a side...
Last post
Well, that is an interesting fix. But now I have to go take a shower after trudging through that forum. :(
2 Replies
20 Views
Last post by Toter
Sat Mar 29, 2025 12:02 pm
I Broke A Connector
Replies: 3
by
fontanaman »
Mon Mar 24, 2025 1:56 pm
First post
The last time I checked the valves on the 17ES, I broke the a cable side connector that plugs into the thermostat sensor, part number 5YP-85790-00-00...
Last post
Once you look into the end of a Sumitomo connector, you'll see how the pins release... normally they use all the same terminals, so it's a matter of...
3 Replies
84 Views
Last post by raYzerman
Mon Mar 24, 2025 6:08 pm
Fork Seals (Again)
Replies: 4
by
RacinRay »
Fri Mar 21, 2025 2:16 pm
First post
I have approximately 80K miles on my '16 and have twice replaced the fork seals. Now, the right side seal is weeping again. If memory serves, this...
Last post
Ah yes, an ES. Well you do need a spring compressor, etc. to get those apart and back together if you do DIY.... note, all USD forks usually have...
4 Replies
122 Views
Last post by raYzerman
Sat Mar 22, 2025 1:01 pm
2015 ES Shock removal
Replies: 50
by
CraigRegs »
Mon Dec 05, 2022 11:57 am
First post
When last we saw Craig, he was riding a spongy rear shock from Iowa to The Last Hurrah in Oregon and back, then to Ohio and on to Alabama for SFO,...
Last post
For future reference, here is a very helpful how-to on ES shock removal without removing fender/airbox, nor the swingarm.
50 Replies
21397 Views
Last post by SkooterG
Fri Mar 21, 2025 4:44 pm
2013-'15 A - Broken fork Compression Valve
Replies: 35
by
raYzerman »
Wed Jan 15, 2025 2:35 pm
First post
Call this a combination of a cautionary tale, technical talk and public service announcement all-in-one...........
Last post
Got the broken valve back with machining to remove the broken part flush, then drilled and tapped 1/2-20 to accept the new steel insert. Insert...
35 Replies
42222 Views
Last post by raYzerman
Mon Mar 03, 2025 7:08 pm
How NOT to Gixxerjasen your FJR forks
Replies: 4
by
raYzerman »
Sat Feb 22, 2025 10:26 am
First post
First the young fella deserves kudos for having the guts to tell us about it. Since then, a few others have managed the same feat, with various...
Last post
I'm just here because I like the name of this thread.
4 Replies
217 Views
Last post by wheatonFJR
Sat Feb 22, 2025 10:08 pm
Race Removal Tool
Replies: 6
by
Canadian FJR »
Mon Nov 11, 2024 6:40 pm
First post
Which one of these fit the FJR?
Last post
You guys are funny.
6 Replies
7463 Views
Last post by Canadian FJR
Tue Nov 12, 2024 3:17 pm
Gear indicator display intermittent
Replies: 19
by
CollingsBob »
Sat Sep 10, 2022 9:12 pm
First post
Today my ‘17ES gear indicator display started going blank intermittently while in 6th gear.
Last post
I replaced the Neutral Switch Assy on my FJR recently. I choose to go with a new one rather than fix the old one. I got it from Rocky Mt ATV for $50....
19 Replies
9905 Views
Last post by fontanaman
Sat Oct 19, 2024 11:59 pm
BackOFF brake module install help
Replies: 16
by
CraigRegs »
Sat Sep 14, 2024 1:54 pm
First post
Oh goodie, an electrical issue...
Last post
Got it to work after hooking up various wiring combos. Using the Wh/R to feed the BO unit, and R/Wh out to the brakes provided the 4 flashes and...
16 Replies
7333 Views
Last post by FJRPittsburgh
Sun Sep 29, 2024 9:18 am
Cruise Control issue
Replies: 11
by
CollingsBob »
Wed Sep 11, 2024 7:29 pm
First post
The dealership contacted me today regarding the cruise control on the ‘17 that I traded in last year and asked me if there was any special trick to...
Last post
CC didn't work on a used '13 FJR I bought years ago. Like you, the light would come on but it wouldn't set. Turned out to be a dirty switch at the...
11 Replies
5278 Views
Last post by rbentnail
Mon Sep 16, 2024 6:51 pm
Resistance
Replies: 12
by
Festus »
Wed Sep 11, 2024 11:43 am
First post
In my ever loving quest to never give up learning FJR tech, I have a coil question for Gen 3 coils and injectors.
Last post
Festus, that spark pattern looks great!
12 Replies
6067 Views
Last post by Festus
Sat Sep 14, 2024 9:14 pm
Resetting the ECU?
Replies: 24
by
Festus »
Fri Sep 06, 2024 7:58 am
First post
I'm hot on the trail of resolving something and the fuel trim data that's added from the MAP and O2 sensor is basically full of data I need to purge...
Last post
Well - I ride 4 hours to go left, right, up, down, and to get Ice cream.
24 Replies
8302 Views
Last post by Festus
Mon Sep 09, 2024 1:14 pm
Morgan Carb Tune Pro
Replies: 32
by
fontanaman »
Fri Apr 05, 2024 6:00 pm
First post
Like many here I have a Morgan Carb Tune Pro to check and adjust my throttle bodies.
Last post
I wasn't clear on who it was responsible for the door plug bolts loose.... wouldn't that be the maintenance crew's job if they had the door off and...
32 Replies
12092 Views
Last post by fontanaman
Fri Sep 06, 2024 11:37 pm
wiring schematic 05
Replies: 7
by
Boston »
Fri Jul 12, 2024 1:37 pm
First post
chasing a intermittent head light problem. Noticeable at night.
Last post
Well the plastics are all back on.
7 Replies
7183 Views
Last post by Boston
Sun Jul 28, 2024 5:27 am
Front Wheel/Handlebar Alignment
Replies: 12
by
FJRoss »
Sat Jun 22, 2024 4:27 pm
First post
I have a slight misalignment of my handlebars relative to the front wheel. With the front wheel pointing straight, the handlebars are very slightly...
Last post
Had a go at it today. Removed the center nut and loosened the two top pinch bolts.
12 Replies
6768 Views
Last post by FJRoss
Thu Jun 27, 2024 10:45 am
Tech 101: Why Fastener Torque Matters "Güdentight" isn't a torque rating
Replies: 20
by
bigjohnsd »
Fri Jun 21, 2024 4:40 pm
First post
Something a lot of weekend wrench-spinners overlook is “torquing” their nuts and bolts. Torque values for fasteners are called out in every shop...
Last post
My introduction to how tight was gleaned originally from using Mechano as a child, where you could make basically anything using nuts and bolts to...
20 Replies
8914 Views
Last post by mcatrophy
Thu Jun 27, 2024 9:43 am
Corbin Smuggler & Yamaha aluminum rear carrier
Replies: 14
by
Madmudder »
Tue May 21, 2024 6:59 pm
First post
Has anyone mounted a Yamaha aluminum rear carrier & been able to install a Corbin Smuggler afterward?
Last post
The Givi rack is completely different than the Yamaha accessory aluminum rack. What works for one won't work for the other.
14 Replies
8161 Views
Last post by Madmudder
Wed Jun 05, 2024 1:18 pm
Final Drive Leak
Replies: 14
by
FJRoss »
Thu Apr 25, 2024 9:17 pm
First post
Not the usual sort where it happens as a result of overfilling or failure of the seal at the input shaft...
Last post
I usually only make it to step 2 which is where everything goes up in flames.
14 Replies
7429 Views
Last post by gixxerjasen
Mon Apr 29, 2024 11:08 am
Sensor Code -Check Engine Light
Replies: 8
by
bill lumberg »
Sun Apr 28, 2024 2:33 pm
First post
Anyone had a gen 3+ FJR pop the CEL, with a code indicating “Multi-axis acceleration sensor A ?
Last post
My reader deciphers the code. No number,
8 Replies
6382 Views
Last post by bill lumberg
Sun Apr 28, 2024 6:35 pm
CODE 19
Replies: 10
by
Tuffy1982 »
Mon Mar 18, 2024 10:58 pm
First post
I’ve got a 2015 with 21k on it, I got a code 19 yesterday but it still started. Today I got a code 19 but it didn’t start. Other threads have said...
Last post
The code 19 is for the sidestand switch, which was intermittent given your start vs. no start..... it's likely the contacts are all cleaned up now...
10 Replies
7224 Views
Last post by Tuffy1982
Mon Mar 25, 2024 12:58 am
Valve check hazards
Replies: 12
by
Gprider »
Wed Mar 13, 2024 6:09 pm
First post
I just did a valve check on my 2016 FJR. Everything went pretty well except for getting the valve cover back on. I had to unhook quite a few...
Last post
Ok, took the bike to a different shop yesterday. I was expecting bad news, but they cleared the codes and the check engine light went off and has...
12 Replies
7490 Views
Last post by Gprider
Thu Mar 21, 2024 10:50 am
Gen 3 surging
Replies: 260
by
Festus »
Sun Oct 04, 2020 7:56 pm
First post
Spent the last 3 days riding with Viper Dad, ride report to follow one day soon.
Last post
So, roughly 3 1/2 years, and you think you’ve got it figured out? Congratulations!! That’s awesome news for Jolene.
260 Replies
173838 Views
Last post by Festus
Mon Mar 18, 2024 7:59 am
12 Replies
7371 Views
Last post by extrememarine
Sun Mar 17, 2024 7:10 pm
Aux light trigger wire on 2016+ LED lights?
Replies: 5
by
Harald »
Sun Aug 08, 2021 1:07 am
First post
Picked up a nice set of 57FA LED aux lights from advmonster to mount on the forks of my 2020 ES. These tiny lights are very bright and have both...
Last post
Just want to report back that this mod is still working great on my 2020 FJR. I put the relay module in a very small project box and sealed it up....
5 Replies
6679 Views
Last post by Harald
Wed Feb 14, 2024 11:45 pm
Forum permissions
You cannot post new topics in this forumcannot reply to topics in this forumcannot edit your posts in this forumcannot delete your posts in this forum
